Use Of Artificial Fine Aggregate In India

Use Of Artificial Fine Aggregate In India

Effect of Waste Foundry Sand (WFS) on the Mechanical ...

2019-7-1  sand”. In India, an estimated 2 million tons of waste foundry sand is produced every year. Use of waste foundry sand as a partial or total replacement for fine aggregate in concrete leads in production of economic, light weight and high strength concrete. Concrete is a material which is

More

IS 3182 (1986): broken brick (burnt clay) fine aggregates ...

2018-11-14  fine aggregate for use in lime mortar. 2. GENERAL QUALITY 2.1 The broken brick fine aggregate shall be prepared from broken/ solid bricks conforming to class designation 50 and above of IS : 1077- 1986*. It shall be free from underburnt clay particles, soluble

More

USE OF GRANULATED BLAST FURNACE SLAG AS FINE

2015-4-27  Research Paper. In India, natural river sand (fine aggregate) is traditionally used in mortars and concrete. However, growing environmental restrictions to the exploitation of sand from riverbeds have resulted in a search for alternative sand, particularly near the larger metropolitan areas.

More

Replacement of fine aggregate with plastic in concrete

2018-5-14  used as the replacement of fine aggregate in the concrete. Concrete cubes were cast taking 10%, 20%, 30 %, 40% 50% of plastic as partial replacement of fine aggregate and tested for 7 28 days of compressive strength of concrete. Keywords: Waste plastic, Compressive strength, Workability. 1. INTRODUCTION

More

Use of Waste Plastic as Fine Aggregate Substitute in

2016-9-9  used as the replacement of fine aggregate in the concrete. Concrete cube and beam were casted taking 10% to 25% of plastic as partial replacement of fine aggregate and tested for 28 days of compressive strength and flexural strength of concrete. 1. INTRODUCTION . The research in to new and innovative waste materials being under taken world-

More

STRENGTH OF CONCRETE CONTAINING DIFFERENT

2016-9-9  tively more uniqueness is achieved in case of artificial sand. The use of manufactured sand in the construction indus-try helps to prevent unnecessary damages to the environ-ment and provide optimum exploitation of the resources. Manufactured sands are made by crushing aggregate to sizes appropriate for use as a fine aggregate. During the

More

Utilization of Plastic Waste in Concrete as Fine Aggregate

2020-3-27  Sand conforming to Zone-II (White Sand) was used as the fine aggregate, as per I.S 383-1970. The sand was air dried and free from any foreign material, earlier than mixing. The sand which was locally available and passing through 4.75mm IS sieve is used. The specific gravity of fine aggregate was 2.60. Locally available river sand conforming to Grading zone-II of IS: 383 –1970.Clean and dry river sand available locally will be used. Sand passing through IS 4.75mm Sieve will be used for casting all the specimens. Fine aggregate is defined as material that will pass from No.4 sieve and will, for the most part, be retained on a No. 200 sieve, for increased workability and for economy as reflected by use of less cement, the fine aggregate should have a rounded shape. The purpose of the fine aggregate

More

RECOVERY AND REUSE OF FINE AGGREGATE FROM

2015-2-28  sand in concrete by PET bottles has been studied [12]. Use of artificial sand, manufactured sand, crushed rock fines etc., as fine aggregate in concrete has been evaluated [13-16]. Recycle of recovered material from the demolition debris as fine aggregate has been investigated by various researchers [17-29]. The recycled fine

More

Experimental Study on Granite Powder as a Replacement

2021-2-27  Fine aggregate consist of mainly sand which may be natural, manufactured or a combination of both. It consists of clean and durable particles generally spherical or cubical in shape. The use of flat or elongated fine aggregate particles should be restricted and also care should be taken to ensure that there are no contaminating substances - dirt, dust, mud, and construction debris - present in fine aggregates. Fine aggregates

More

Construction Aggregates at Best Price in India

Kalher Thane, Mumbai. Unit 8, Building B, Ground Floor, Rajlaxmi Commercial Complex Agra Road, Kalher Thane, Mumbai - 421302, Dist. Mumbai, Maharashtra. TrustSEAL Verified Verified Exporter. View Mobile Number. Call +91-8047029243. Contact

More

Replacement of fine aggregate with plastic in concrete

2018-5-14  the effects of using plastic waste as an alternative of Fine Aggregate. Disposal of plastic waste in the environment is considered to be a big problem due to the rapid growth of population in countries like India the disposing of solid waste is a major problem in our daily life. Solid waste management is one of the major environmental concerns.

More

IS 3182 (1986): broken brick (burnt clay) fine aggregates ...

2018-11-14  fine aggregate for use in lime mortar. 2. GENERAL QUALITY 2.1 The broken brick fine aggregate shall be prepared from broken/ solid bricks conforming to class designation 50 and above of IS : 1077- 1986*. It shall be free from underburnt clay particles, soluble

More

INVESTIGATING THE PROPERTIES OF M- 30 GRADE

2021-5-24  The positive use of artificial sand will conserve natural resources. The choice of fine ... In India, conventional concrete is produced by using natural sand, cement, coarse aggregate, and ... Fine aggregate normally consists of manufactured sand. The M-Sand (MS) is a byproduct of the ...

More

Effect of Partial Replacement of Fine Aggregate with ...

2018-4-24  The use of manufactured sand has been acknowledged as one of the building material. The above investigation exhibits the utilization of produced sand in concrete at different replacement proportions. To reduce use of natural sand we are replacing natural sand to 0%, 25%, 50%, 75% of artificial sand for M20, M25 grade of concrete.

More

EXPERIMENTAL STUDY ON COMPARATIVE ANALYSIS OF

2018-11-8  Fine aggregate In the present investigation, river sand taken from Vaigai river, which was available at Madurai, was used as fine aggregate. The specific gravity of fine aggregate was 2.57. Coarse aggregate Coarse aggregates used in this study were crushed blue granite stone aggregate of size 20mm. The specific gravity of coarse aggregate was 2.7.

More

Use of Waste Plastic as Fine Aggregate Substitute in

2016-9-9  used as the replacement of fine aggregate in the concrete. Concrete cube and beam were casted taking 10% to 25% of plastic as partial replacement of fine aggregate and tested for 28 days of compressive strength and flexural strength of concrete. 1. INTRODUCTION . The research in to new and innovative waste materials being under taken world-

More

Literature Review on Different Plastic Waste Materials Use ...

2018-6-19  Fine aggregate in the mix proportion of concrete was replaced with plastic bag waste sand at 10%, 20%, 30% and 40% whereas other concrete materials remain same for all four mixes. In fresh properties of concrete it was observed from the results of slump test

More

RECOVERY AND REUSE OF FINE AGGREGATE FROM

2015-2-28  sand in concrete by PET bottles has been studied [12]. Use of artificial sand, manufactured sand, crushed rock fines etc., as fine aggregate in concrete has been evaluated [13-16]. Recycle of recovered material from the demolition debris as fine aggregate has been investigated by various researchers [17-29]. The recycled fine

More

IS 383 (1970): Specification for Coarse and Fine ...

2018-11-14  2.1.2 Crushed Stone Sand - Fine aggregate produced by crushing hard stone. 2.1.3 Crushed Grace1 Sand - line aggregate produced by crushing natural gravel. . 2.2 Coarse Aggregate -- Aggregate most of which is retained on 4*75-mm IS Sieve and containing only so

More

Construction Aggregates at Best Price in India

Call +91-8048764644. Contact Supplier Request a quote. White 6mm Construction Aggregates. ₹ 450/ Ton Get Latest Price. Color: White. Country of Origin: Made in India. To aggregate is to collect many units into one. If you're writing a novel, you might create a character who is an aggregate

More

IS 3182 (1986): broken brick (burnt clay) fine aggregates ...

2018-11-14  fine aggregate for use in lime mortar. 2. GENERAL QUALITY 2.1 The broken brick fine aggregate shall be prepared from broken/ solid bricks conforming to class designation 50 and above of IS : 1077- 1986*. It shall be free from underburnt clay particles, soluble

More

INVESTIGATING THE PROPERTIES OF M- 30 GRADE

2021-5-24  The positive use of artificial sand will conserve natural resources. The choice of fine ... In India, conventional concrete is produced by using natural sand, cement, coarse aggregate, and ... Fine aggregate normally consists of manufactured sand. The M-Sand (MS) is a byproduct of the ...

More

Effect of Partial Replacement of Fine Aggregate with ...

2018-4-24  The use of manufactured sand has been acknowledged as one of the building material. The above investigation exhibits the utilization of produced sand in concrete at different replacement proportions. To reduce use of natural sand we are replacing natural sand to 0%, 25%, 50%, 75% of artificial sand for M20, M25 grade of concrete.

More

Literature Review on Different Plastic Waste Materials Use ...

2018-6-19  Fine aggregate in the mix proportion of concrete was replaced with plastic bag waste sand at 10%, 20%, 30% and 40% whereas other concrete materials remain same for all four mixes. In fresh properties of concrete it was observed from the results of slump test

More

RECOVERY AND REUSE OF FINE AGGREGATE FROM

2015-2-28  sand in concrete by PET bottles has been studied [12]. Use of artificial sand, manufactured sand, crushed rock fines etc., as fine aggregate in concrete has been evaluated [13-16]. Recycle of recovered material from the demolition debris as fine aggregate has been investigated by various researchers [17-29]. The recycled fine

More

EXPERIMENTAL STUDY ON COMPARATIVE ANALYSIS OF

2018-11-8  Fine aggregate In the present investigation, river sand taken from Vaigai river, which was available at Madurai, was used as fine aggregate. The specific gravity of fine aggregate was 2.57. Coarse aggregate Coarse aggregates used in this study were crushed blue granite stone aggregate of size 20mm. The specific gravity of coarse aggregate was 2.7.

More

Use Of Recycled Aggregate In Concrete – IJERT

2013-1-30  This paper reports the basic properties of recycled fine aggregate and recycled coarse aggregate also compares these properties with natural aggregates. Basic changes in all aggregate properties are determined and their effects on concreting work are discussed at length. ... India Use for embankment purpose in bridges, roads etc. up to 3% to ...

More

IS 383 (1970): Specification for Coarse and Fine ...

2018-11-14  2.1.2 Crushed Stone Sand - Fine aggregate produced by crushing hard stone. 2.1.3 Crushed Grace1 Sand - line aggregate produced by crushing natural gravel. . 2.2 Coarse Aggregate -- Aggregate most of which is retained on 4*75-mm IS Sieve and containing only so

More

artificial sand as fine aggregate - superprimeurs

replacement of natural with artificial fine aggregate in ... artificial sand as a fine aggregate philippines. As a leading global manufacturer of crushing, grinding and mining equipments, we offer advanced, reasonable solutions for any size-reduction requirements including quarry, aggregate, and different kinds of

More

Characteristics of Cement Mortar with M-sand as ...

2018-1-1  M-sand is artificially manufactured fine aggregate obtained from a source material, purpose designed for use in concrete and mortar or for other specific products such as blocks. It is made by feeding stones of variable sizes to primary and secondary crushers (called Jaw crusher and Cone crusher), for size reduction.

More